Date
|
Hours
|
Work Log Summary
|
Details
|
11-06-2010
|
1.00
|
Brake Lever
|
Details
|
|
|
09-01-2010
|
3.00
|
Prep for Certification
|
Details
|
|
|
|
08-21-2010
|
0.50
|
Delivery to Searcy, AK
|
Details
|
|
|
|
08-17-2010
|
1.00
|
Dead Battery
|
Details
|
|
|
|
08-13-2010
|
3.00
|
Rotor Tachometer
|
Details
|
|
|
|
08-07-2010
|
1.00
|
Rotor Tach
|
Details
|
|
|
|
08-06-2010
|
2.00
|
Inspection and fixes
|
Details
|
|
|
|
07-27-2010
|
1.50
|
Upper control rods
|
Details
|
|
|
|
07-26-2010
|
0.50
|
Starter Fix Test
|
Details
|
|
|
|
07-26-2010
|
1.00
|
Drill rotor stops
|
Details
|
|
|
|
07-25-2010
|
4.00
|
Replaced the MLG strut
|
Details
|
|
|
|
07-20-2010
|
2.00
|
New MLG Strut
|
Details
|
|
|
|
07-09-2010
|
2.00
|
Failed at beefing up MLG
|
Details
|
|
|
|
07-08-2010
|
2.00
|
Fix Starter Bendix Gear
|
Details
|
|
|
|
07-06-2010
|
1.00
|
Repack bearings
|
Details
|
|
|
|
07-05-2010
|
1.00
|
Repack beaing
|
Details
|
|
|
|
07-03-2010
|
6.00
|
Engine Starter and Door handle Fitting
|
Details
|
|
|
|
06-27-2010
|
4.00
|
PSRU and Fuel Sender
|
Details
|
|
|
|
06-25-2010
|
2.00
|
PSRU replacement and Fuel Level
|
Details
|
|
|
|
06-22-2010
|
2.00
|
Replace thermostat and battery
|
Details
|
|
|
|
06-21-2010
|
3.00
|
Setting max RPM
|
Details
|
|
|
|
06-20-2010
|
0.50
|
Set pitch to 14 degrees
|
Details
|
|
|
|
06-19-2010
|
3.00
|
Static Display at EAA 72 Chapter Breakfast
|
Details
|
|
|
06-18-2010
|
1.00
|
Aircraft weighing
|
Details
|
|
|
|
06-10-2010
|
1.00
|
Replace oil pressure wire
|
Details
|
|
|
|
06-09-2010
|
1.00
|
Install Windshield
|
Details
|
|
|
|
06-08-2010
|
1.00
|
Windshield installation
|
Details
|
|
|
|
06-06-2010
|
2.00
|
First Engine runs
|
Details
|
|
|
06-05-2010
|
4.00
|
Install windows in doors
|
Details
|
|
|
05-23-2010
|
4.00
|
Load gyro onto trailer
|
Details
|
|
|
|
05-22-2010
|
1.00
|
Install pilot door seal
|
Details
|
|
|
|
05-20-2010
|
6.50
|
Transponder Check and seal fuel tanks
|
Details
|
|
|
05-18-2010
|
2.00
|
Install Left Door seal
|
Details
|
|
|
05-17-2010
|
4.00
|
Anti-serve, Rudder, cable tension
|
Details
|
|
|
05-16-2010
|
6.00
|
Anti-Servo Tab
|
Details
|
|
|
|
05-10-2010
|
0.75
|
Engine Ground
|
Details
|
|
|
|
05-08-2010
|
3.00
|
New Battery and wire labels
|
Details
|
|
|
05-05-2010
|
1.00
|
Baseline compression
|
Details
|
|
|
|
05-04-2010
|
0.50
|
Compass pad adjustment
|
Details
|
|
|
|
05-03-2010
|
1.00
|
Paint Compas leveler
|
Details
|
|
|
|
05-01-2010
|
1.00
|
Level Compass
|
Details
|
|
|
04-26-2010
|
0.50
|
Wire Clean up
|
Details
|
|
|
|
04-22-2010
|
6.00
|
Wire harness clean up
|
Details
|
|
|
|
04-20-2010
|
2.00
|
Hunt for missing power
|
Details
|
|
|
|
04-19-2010
|
1.00
|
Connect instruments to power
|
Details
|
|
|
|
04-18-2010
|
1.00
|
Instrument grounds
|
Details
|
|
|
|
04-17-2010
|
6.00
|
label wires
|
Details
|
|
|
|
04-13-2010
|
1.00
|
Connect pitot tube to Alt Encoder
|
Details
|
|
|
04-12-2010
|
3.00
|
Route wires from overhead to instrument pod
|
Details
|
|
|
04-11-2010
|
3.00
|
Continuing with the Overhead Switch Panel
|
Details
|
|
|
04-10-2010
|
3.50
|
Overhead panel switch wiring
|
Details
|
|
|
04-10-2010
|
4.00
|
GPS Mount
|
Details
|
|
|
|
04-09-2010
|
0.80
|
Strobe Light and Position Light Power and Ground
|
Details
|
|
|
|
04-01-2010
|
2.30
|
Position Light leads
|
Details
|
|
|
|
03-31-2010
|
1.00
|
Overhead ground block
|
Details
|
|
|
|
03-27-2010
|
3.00
|
Rotor Tach Sensor
|
Details
|
|
|
|
03-26-2010
|
1.50
|
Change CB
|
Details
|
|
|
|
03-25-2010
|
3.00
|
Tail number, Exp sticker, Alt Ign wire
|
Details
|
|
|
|
03-20-2010
|
6.00
|
PTT, Hobbes, Master Switch, Starter
|
Details
|
|
|
|
03-16-2010
|
4.00
|
RG-400 Transponder cable
|
Details
|
|
|
|
03-14-2010
|
1.00
|
Tail Decals
|
Details
|
|
|
03-13-2010
|
4.00
|
Fab cable for Transponder to Encoder
|
Details
|
|
|
03-10-2010
|
2.50
|
Attach headphone jacks to overhead
|
Details
|
|
|
|
03-09-2010
|
2.00
|
Overhead panel
|
Details
|
|
|
|
03-07-2010
|
3.00
|
Strobe Iight
|
Details
|
|
|
|
03-06-2010
|
6.00
|
Wire position / strobe lights
|
Details
|
|
|
|
03-04-2010
|
3.50
|
Overhead panel, Instrument panel
|
Details
|
|
|
|
03-03-2010
|
3.50
|
Redo Radio
|
Details
|
|
|
|
03-02-2010
|
2.50
|
Troubleshoot Pilot Mic
|
Details
|
|
|
|
03-01-2010
|
4.50
|
Radio Ant, Landing Light, Circuit Breakers
|
Details
|
|
|
02-25-2010
|
4.00
|
FL-760 harnes to Headphone jacks
|
Details
|
|
|
|
02-24-2010
|
4.00
|
Headphone jack harness
|
Details
|
|
|
|
02-23-2010
|
4.00
|
Redo the shield ground on the radio harness
|
Details
|
|
|
|
02-22-2010
|
4.00
|
Radio harness
|
Details
|
|
|
|
02-07-2010
|
5.00
|
Fab starter cables
|
Details
|
|
|
02-06-2010
|
3.00
|
Engine Harness to ECM
|
Details
|
|
|
02-03-2010
|
4.00
|
Preparing Instru Panel mount
|
Details
|
|
|
|
02-02-2010
|
3.00
|
Populated the instrument panel
|
Details
|
|
|
01-30-2010
|
2.00
|
relocate master relay
|
Details
|
|
|
01-28-2010
|
6.00
|
Study drawings
|
Details
|
|
|
|
01-24-2010
|
1.00
|
Repainted the instrument panel with flat blac
|
Details
|
|
|
|
01-23-2010
|
3.00
|
Instrument panel cut outs
|
Details
|
|
|
|
01-01-2010
|
1.50
|
Mount Nav/Pos Lights
|
Details
|
|
|
|
12-30-2009
|
2.00
|
Install VHF antenna
|
Details
|
|
|
12-21-2009
|
1.00
|
Mount the transponder antenna
|
Details
|
|
|
12-21-2009
|
1.00
|
Fab Transponder Groundplane
|
Details
|
|
|
12-15-2009
|
2.00
|
Reinstall muffler bracket, radiator hose
|
Details
|
|
|
12-09-2009
|
1.50
|
Reinstall lower sprocket and prop
|
Details
|
|
|
12-08-2009
|
2.00
|
Fab Exhaust bracket
|
Details
|
|
|
|
12-07-2009
|
2.00
|
Muffler bracket
|
Details
|
|
|
|
12-06-2009
|
4.00
|
Redo the PSRU, Muffler bracket
|
Details
|
|
|
|
12-05-2009
|
2.00
|
Wire harness and mounting relays
|
Details
|
|
|
|
12-01-2009
|
4.00
|
Muffler Modification
|
Details
|
|
|
|
11-28-2009
|
4.00
|
Replace bolts on prop horse collar
|
Details
|
|
|
|
11-18-2009
|
1.00
|
Remove PSRU sprocket
|
Details
|
|
|
|
10-26-2009
|
2.50
|
Panel mount with ECU and SkyDat Gx2 mod
|
Details
|
|
|
10-25-2009
|
3.00
|
Electrical mounting panel
|
Details
|
|
|
10-23-2009
|
2.00
|
Tow Bar
|
Details
|
|
|
|
10-21-2009
|
4.50
|
Electrical, engine harness, heater hose
|
Details
|
|
|
10-19-2009
|
3.00
|
Headlight, exhaust header
|
Details
|
|
|
10-16-2009
|
1.50
|
Engine Wiring
|
Details
|
|
|
|
10-15-2009
|
2.00
|
Fuel Strainer
|
Details
|
|
|
10-14-2009
|
2.00
|
Clean Gas Tanks
|
Details
|
|
|
|
10-12-2009
|
3.00
|
Secure radiator hose from exhaust pipe
|
Details
|
|
|
10-11-2009
|
2.00
|
Set 12 degrees on prop
|
Details
|
|
|
|
10-10-2009
|
3.00
|
Heater Valves
|
Details
|
|
|
10-09-2009
|
2.50
|
Reconfig Fuel Return
|
Details
|
|
|
10-08-2009
|
2.50
|
Fuel Level Sensor and Battery Tie Down
|
Details
|
|
|
10-07-2009
|
2.50
|
Battery tie down and 12v socket
|
Details
|
|
|
10-06-2009
|
2.00
|
Install 12v socket onto the Pod
|
Details
|
|
|
10-05-2009
|
2.50
|
Cooling Hoses
|
Details
|
|
|
10-04-2009
|
3.00
|
Overflow, exhaust,
|
Details
|
|
|
10-03-2009
|
8.00
|
Paint Pod and support
|
Details
|
|
|
10-02-2009
|
5.00
|
Pod, Grounding Point
|
Details
|
|
|
|
10-01-2009
|
3.00
|
Pin control elbows
|
Details
|
|
|
09-30-2009
|
2.50
|
Redo Flight controls
|
Details
|
|
|
09-26-2009
|
4.00
|
Re-rigging flight controls
|
Details
|
|
|
|
09-23-2009
|
2.00
|
Install prerotator to rotor head
|
Details
|
|
|
09-22-2009
|
0.40
|
Safety wire Bendix assembly
|
Details
|
|
|
|
09-21-2009
|
0.40
|
Install pinon gear in Bendix pre-rotator
|
Details
|
|
|
09-19-2009
|
2.00
|
Prerotator
|
Details
|
|
|
09-18-2009
|
4.00
|
Add tach
|
Details
|
|
|
09-16-2009
|
2.50
|
Rig Controls
|
Details
|
|
|
|
09-14-2009
|
2.00
|
Strip Pod Paint, Pinon Gear, Control
|
Details
|
|
|
|
09-12-2009
|
6.00
|
Trim Controls
|
Details
|
|
|
|
09-11-2009
|
3.00
|
Finished Pre-rotator hand control cable
|
Details
|
|
|
09-10-2009
|
3.00
|
Pre-rotator handle, fuel lines
|
Details
|
|
|
09-07-2009
|
8.00
|
fuel lines, rotor brake cable
|
Details
|
|
|
09-06-2009
|
8.00
|
Rotor Head
|
Details
|
|
|
|
09-02-2009
|
1.00
|
Rigging Tool
|
Details
|
|
|
|
08-28-2009
|
1.00
|
Route fuel cell vent
|
Details
|
|
|
|
08-23-2009
|
3.00
|
Throttle cables
|
Details
|
|
|
|
08-22-2009
|
3.00
|
Install Brake Cables
|
Details
|
|
|
08-17-2009
|
1.00
|
Install Pit0t
|
Details
|
|
|
08-16-2009
|
1.00
|
Redo fuel lines with adel clamps
|
Details
|
|
|
08-15-2009
|
1.00
|
New tail turnbuckles
|
Details
|
|
|
08-12-2009
|
1.50
|
Rotor Brake
|
Details
|
|
|
08-11-2009
|
0.50
|
Rotor Brake Lever
|
Details
|
|
|
|
08-10-2009
|
4.00
|
Reassemble Drawings
|
Details
|
|
|
|
08-09-2009
|
12.00
|
Rudder cables
|
Details
|
|
|
08-08-2009
|
3.00
|
Rudder control cables
|
Details
|
|
|
08-06-2009
|
1.00
|
Reattach tail support
|
Details
|
|
|
|
08-05-2009
|
2.00
|
Remove tail and fix swivel bolt cotterpin hole
|
Details
|
|
|
08-04-2009
|
3.00
|
Drill swivel bolt for cotter pin
|
Details
|
|
|
|
07-26-2009
|
1.50
|
Rotor Brake
|
Details
|
|
|
07-25-2009
|
5.50
|
MLG Brake Lever
|
Details
|
|
|
07-05-2009
|
4.00
|
Brakes
|
Details
|
|
|
|
07-04-2009
|
7.00
|
Throtttle and control lock
|
Details
|
|
|
07-03-2009
|
10.00
|
Throttle controls
|
Details
|
|
|
|
07-03-2009
|
1.00
|
Paint Instrument Panel
|
Details
|
|
|
|
07-01-2009
|
3.00
|
Radiator Protector
|
Details
|
|
|
|
06-28-2009
|
15.00
|
New Heater and installation
|
Details
|
|
|
06-28-2009
|
0.50
|
Fuel line from filter to low pressure switch
|
Details
|
|
|
06-25-2009
|
1.00
|
Heater installation
|
Details
|
|
|
06-25-2009
|
1.00
|
fuel hoses from pump to filter
|
Details
|
|
|
|
06-23-2009
|
1.00
|
Install Fuel Filters
|
Details
|
|
|
06-23-2009
|
1.00
|
Fit heater
|
Details
|
|
|
06-22-2009
|
3.00
|
Deliver Wings to Paint Shop
|
Details
|
|
|
06-18-2009
|
2.00
|
Low Pressure Switch
|
Details
|
|
|
06-17-2009
|
4.00
|
Pedal Support
|
Details
|
|
|
06-14-2009
|
7.00
|
Pitman arm, raditator
|
Details
|
|
|
06-10-2009
|
1.00
|
Mount Fuel Pump
|
Details
|
|
|
06-08-2009
|
2.00
|
Pitman arm
|
Details
|
|
|
|
06-06-2009
|
8.00
|
Radiator Prep
|
Details
|
|
|
06-06-2009
|
7.00
|
Pedal kickplate
|
Details
|
|
|
06-03-2009
|
2.00
|
Control Stick
|
Details
|
|
|
|
05-31-2009
|
3.00
|
Seats
|
Details
|
|
|
05-28-2009
|
1.00
|
Clean up glue on wing
|
Details
|
|
|
05-24-2009
|
5.00
|
Grommet, chair rails
|
Details
|
|
|
|
05-22-2009
|
8.00
|
Nose gear fitting modified
|
Details
|
|
|
05-21-2009
|
4.00
|
Nose Gear cover for cabin hole
|
Details
|
|
|
05-20-2009
|
1.50
|
Install fuel cell drains
|
Details
|
|
|
|
05-20-2009
|
2.00
|
Drilled Horizontal Stab
|
Details
|
|
|
|
05-17-2009
|
3.50
|
Painted misc parts
|
Details
|
|
|
|
05-13-2009
|
4.00
|
Trim Horizontal Stab for attachment
|
Details
|
|
|
05-12-2009
|
5.00
|
Install Cabin
|
Details
|
|
|
05-07-2009
|
4.00
|
Install rubber hoses
|
Details
|
|
|
05-05-2009
|
0.50
|
Complete idler installation
|
Details
|
|
|
05-05-2009
|
3.00
|
Begin work on tail
|
Details
|
|
|
|
05-02-2009
|
0.00
|
New tail arrives
|
Details
|
|
|
04-25-2009
|
1.50
|
Install Fuel Return and Vent
|
Details
|
|
|
|
04-13-2009
|
0.00
|
FL-760 VHF radio
|
Details
|
|
|
|
04-11-2009
|
5.50
|
Try to install wing (tail feathers) and fuel plumb
|
Details
|
|
|
04-10-2009
|
5.50
|
Lower Seat Rails
|
Details
|
|
|
04-07-2009
|
3.50
|
Pick up Cabin/Tail from paint shop
|
Details
|
|
|
04-04-2009
|
1.00
|
Tail Support
|
Details
|
|
|
|
04-01-2009
|
3.00
|
Add radio to instrument panel
|
Details
|
|
|
|
03-29-2009
|
3.00
|
Pre-rotator belt
|
Details
|
|
|
|
03-29-2009
|
2.00
|
Install Garmin 320A mounting bracket
|
Details
|
|
|
03-28-2009
|
2.00
|
Pod repair
|
Details
|
|
|
03-27-2009
|
3.00
|
Transponder
|
Details
|
|
|
03-26-2009
|
6.00
|
Rebuild Instrument Pod
|
Details
|
|
|
|
03-22-2009
|
5.00
|
Cut Instrument Panel
|
Details
|
|
|
03-19-2009
|
2.00
|
Align Engine Mounts
|
Details
|
|
|
|
03-17-2009
|
0.00
|
Cabin Paint Photos
|
Details
|
|
|
03-15-2009
|
1.00
|
Install EJ25 rubber isolators
|
Details
|
|
|
|
03-14-2009
|
3.00
|
Rivet heater
|
Details
|
|
|
|
03-14-2009
|
1.00
|
PVC, Battery box bracket
|
Details
|
|
|
|
03-13-2009
|
2.50
|
Battery Box, Prerotator, Bearing Support
|
Details
|
|
|
03-12-2009
|
4.00
|
Pre-rotator and Bearing support
|
Details
|
|
|
03-11-2009
|
10.00
|
Pre-rotator and Instrument
|
Details
|
|
|
03-10-2009
|
1.50
|
Pre-rotator
|
Details
|
|
|
|
03-03-2009
|
9.50
|
Engine Bearing Support
|
Details
|
|
|
|
02-26-2009
|
2.00
|
Cyclic Stick Components
|
Details
|
|
|
|
02-25-2009
|
6.00
|
Started small assemblies
|
Details
|
|
|
|
02-25-2009
|
8.00
|
Misc
|
Details
|
|
|
|
02-24-2009
|
0.50
|
Garmin GTX 320a Transponder
|
Details
|
|
|
|
02-24-2009
|
2.00
|
Cut the Control Stick
|
Details
|
|
|
|
02-24-2009
|
2.00
|
Control stick and control rods
|
Details
|
|
|
|
02-20-2009
|
4.00
|
Cyclic Control System
|
Details
|
|
|
|
02-19-2009
|
2.00
|
Flanged Bushing Installation
|
Details
|
|
|
02-18-2009
|
12.00
|
Post keel paint job
|
Details
|
|
|
|
02-17-2009
|
3.50
|
Control Rods
|
Details
|
|
|
|
02-12-2009
|
3.00
|
Sand tail feathers
|
Details
|
|
|
|
02-11-2009
|
7.00
|
Seat rails and peddles
|
Details
|
|
|
02-11-2009
|
0.00
|
Paint Shop Pictures - Blue on Frame
|
|
|
|
02-11-2009
|
10.00
|
Paint inside of Cabin
|
Details
|
|
|
02-11-2009
|
4.00
|
Install seat railing before painting inside of Cab
|
Details
|
|
|
|
02-11-2009
|
4.00
|
Engine research
|
Details
|
|
|
|
02-05-2009
|
5.00
|
Mount Doors
|
Details
|
|
|
|
02-02-2009
|
1.00
|
Sand tail feather fillets.
|
Details
|
|
|
|
02-02-2009
|
1.00
|
Install pilot side window into door frame
|
Details
|
|
|
|
01-26-2009
|
3.00
|
Fillet on bottom of tail feathers
|
|
|
|
|
01-24-2009
|
2.00
|
Drill support bolts for Horizontal Stab
|
Details
|
|
|
01-23-2009
|
3.00
|
|
Details
|
|
|
|
01-22-2009
|
0.50
|
Understanding fuel system
|
Details
|
|
|
|
01-21-2009
|
3.00
|
Understanding Fuel-transfer system
|
Details
|
|
|
|
01-19-2009
|
1.00
|
Fuel filler system
|
Details
|
|
|
01-17-2009
|
1.00
|
Engine rod support
|
Details
|
|
|
|
01-14-2009
|
2.00
|
Fillet on tail group
|
Details
|
|
|
01-13-2009
|
4.00
|
Mount Alternator on new mount
|
Details
|
|
|
|
01-12-2009
|
2.00
|
Engine Support Rods
|
Details
|
|
|
|
01-10-2009
|
10.00
|
Cabin work
|
Details
|
|
|
|
01-08-2009
|
3.00
|
Door handles
|
Details
|
|
|
|
01-07-2009
|
1.00
|
Door hinge
|
Details
|
|
|
|
01-03-2009
|
4.00
|
Alternator Fitting
|
Details
|
|
|
|
01-02-2009
|
3.00
|
Mount new 70 amp Alt
|
Details
|
|
|
01-01-2009
|
1.00
|
Review heater install instructions
|
Details
|
|
|
|
01-01-2009
|
3.00
|
Pod Support Doubler
|
Details
|
|
|
12-30-2008
|
1.50
|
Filling void between VS & HS with glass cloth
|
|
|
|
12-28-2008
|
10.00
|
Fit cabin brackets to keel
|
Details
|
|
|
12-27-2008
|
1.50
|
Glue HS and VS together
|
|
|
|
12-26-2008
|
1.50
|
Prep for glue HS to VS
|
|
|
|
|
12-26-2008
|
3.00
|
Fit Cabin onto keel
|
Details
|
|
|
12-25-2008
|
2.00
|
Glue VS & HS fittings w/o attaching HS
|
|
|
|
|
12-24-2008
|
0.50
|
Installed Alternator Bracket
|
Details
|
|
|
|
12-22-2008
|
2.00
|
Install oil pressure & temp sensor
|
|
|
|
|
12-20-2008
|
4.00
|
Mounted Engine on temp stand
|
Details
|
|
|
12-20-2008
|
10.00
|
Cut Cabin for keel
|
Details
|
|
|
12-19-2008
|
2.50
|
Cut HS and fit with end caps
|
Details
|
|
|
12-15-2008
|
3.00
|
Trim HS to VS
|
Details
|
|
|
12-15-2008
|
3.00
|
Trim and fit HS
|
|
|
|
|
12-12-2008
|
5.00
|
Trim and fit HS
|
|
|
|
|
12-10-2008
|
1.00
|
Glue HS trailing edge after trimming to size
|
Details
|
|
|
|
12-09-2008
|
1.50
|
Fill voids on HS leading edge
|
|
|
|
|
12-07-2008
|
3.00
|
Worked on the spar on the vertical tail
|
Details
|
|
|
12-05-2008
|
2.00
|
Shaping glue on leading edge of Horizontal Stab
|
Details
|
|
|
12-04-2008
|
3.00
|
Glue Horizontal Stab top skin
|
Details
|
|
|
12-03-2008
|
2.00
|
Unpacked Boxes
|
|
|
|
|
12-03-2008
|
1.00
|
Setup Horizontal Stab for gluing
|
Details
|
|
|
12-02-2008
|
0.00
|
Purchase Kit from Garret Nickolson
|
Details
|
|
